VAUXHALL OPEL
Agila / Astra / Corsa / Frontera / Meriva / Signum / Tigra / Vectra / Zafira / Insignia / VXR
NON START WARNING LIGHT FLASHING
Non start, spanner or engine management light flashing, the micro chip in the key has been not reconised. Has the remote control key fob's been apart if so you have probably lost the micro chip see picture.
BURNING SMELL NON START
Non start smell of burning under bonnet, the starter motor has burnt out due to the ignition switch seizing and not returning to run position, this leaves the starter motor running and burns it out. Try WD40 to un-seize lock, if not replace or will burn out new starter motor.
STEERING LOCK JAMMED
Steering lock jammed particularly in hot weather, lubricate with WD40 then with key removed use a rubber hammer hit middle of lock (Round piece key goes in) this should jar lock and un-jam. After two or three tries and the lock should un-jam.
RATTLING ENGINE MANAGEMENT LIGHT ON
Engine running rough, rattling and engine management light on, check oil level is not low, this will cause low oil pressure which will make hydraulic tappets rattle, the knock sensor (pinking sensor) will hear this and put engine management light on.
DIESEL SMOKING
Rough running (smoking if diesel ) can be caused by EGR valve (Exhaust Gas Recirculation) sticking open try removing pipe or wires and tapping valve to un-jam. More on Vauxhall EGR's
CORSA 2000-03 NO GAUGES OR DASH BOARD-LIGHTS
Corsa 2000-03 no gauges or dash board-lights probably won't start, push on gauges, everything should come back and car starts. Bad connection on the back instruments cause immobilizer to cut in.
EARLY FRONTERA NON START
Check if the interior light switch is working properly (e.g. no light) the immobilizer will not disarm if it does not, clean switch on door pillars with WD40 to light works, lock and unlock car and retry to start.